{"id":9605,"date":"2020-10-13T04:01:47","date_gmt":"2020-10-13T04:01:47","guid":{"rendered":"http:\/\/sgx02.dewaweb.com\/~multimor\/?page_id=9605"},"modified":"2021-01-21T07:45:05","modified_gmt":"2021-01-21T07:45:05","slug":"perata-lantai","status":"publish","type":"page","link":"https:\/\/www.multimortar.com\/en\/perata-lantai\/","title":{"rendered":"Floor Leveler"},"content":{"rendered":"
<\/span><\/div>
<\/span><\/div>
<\/span><\/div>
<\/span><\/div>
<\/span><\/div>
<\/span><\/div>
<\/span><\/div>
<\/span><\/div>

FLOORING<\/h3>\n\t
\n\t\t
\n\t\t\t

<\/strong>MM-501<\/strong><\/p>\n\n\t\t<\/div>\n\t<\/div>\n\n\t

\n\t\t
\n\t\t\t

Instant cement with a special formula for leveling floors, increasing floor height or as a work floor before installing ceramics.<\/p>\n\n\t\t<\/div>\n\t<\/div>\n<\/div><\/div><\/div><\/div><\/div><\/section><\/div>

<\/span><\/div>\n\t
\n\t\t\n\t\t
\n\t\t\t
\"MM-501\"<\/div>\n\t\t<\/figure>\n\t<\/div>\n
<\/span><\/div><\/div><\/div><\/div>
<\/span><\/div>
<\/span><\/div>\r\n\t

\r\n\t\t\t\r\n\t\t\t\tHOW TO USE\r\n\t\t\t<\/span>\r\n\t\t<\/h3>

1. Clean the surface from dirt that can reduce adhesion.
\n2. Pour MM-501 into clean water gradually.
\n3. Mix ratio: 9-9.5 liter\/40 kg. Stir the mixture until smooth.
\n4. Use a long margin of aluminum steel.
\n5. If the surface of the brick is too dry, make it wet with clean water.
\n6. Ketebalan aplikasi yang disarankan adalah 3 mm untuk ukuran keramik maksimum 60 x60 cm.
\n7. Pot life: 45 \u2013 60 minutes.<\/p>\n

WORKING TOOLS<\/strong>
\nTrowel, long margin steel or aluminum, hand mixer.<\/p>\n<\/div><\/div><\/div>\r\n\t

\r\n\t\t\t\r\n\t\t\t\tBENEFITS\r\n\t\t\t<\/span>\r\n\t\t<\/h3>

1. Has high adhesion and is plastic when applied.
\n2. Replace the ceramic without disassembling it.
\n3. Resistant to expansion and contraction.
\n4. Strong to withstand compressive loads on the ceramic surface.
\n5. Avoid popping (loose ceramics).
\n6. Consistent quality.<\/p>\n<\/div><\/div><\/div>\r\n\t

\r\n\t\t\t\r\n\t\t\t\tSPEAD COVERAGE\r\n\t\t\t<\/span>\r\n\t\t<\/h3>

\u00b1 1,2 m2 \/ 40 kg \/ 20 mm<\/p>\n

COMPRESSIVE STRENGTH<\/strong>
\nDIN 18555 Part 3 : 2-5 N\/mm2 @28 days
\nWATER RETENTION<\/strong>
\nDIN 18555 part 3 : > 95%
\nDRYING SHRINKAGE<\/strong>
\nASTM C 596-01 : < 0,1%<\/p>\n

USE<\/strong>
\nMM-501 can be applied on a variety of surfaces, namely:
\n1. Solid and level ground
\n2. Concrete floor surface
\n3. Rebate floor surface<\/p>\n<\/div><\/div><\/div>\r\n\t

\r\n\t\t\t\r\n\t\t\t\tSTORAGE\r\n\t\t\t<\/span>\r\n\t\t<\/h3>

Store in a closed and dry room. Avoid excessive stacking, maximum 8 stacks per pallet (maximum 2 pallet stacks).<\/p>\n

EXPIRED TIME<\/strong>
\n12 months when stored in closed and dry packaging<\/p>\n<\/div><\/div><\/div><\/div><\/div><\/div><\/div><\/div><\/section><\/div>

<\/span><\/div>
<\/span><\/span><\/span><\/span>\n<\/div>
<\/span><\/div>
<\/span><\/div>

EXPOSED FLOOR FLOORING<\/h3>\n\t
\n\t\t
\n\t\t\t

<\/strong>MM-502<\/strong><\/p>\n\n\t\t<\/div>\n\t<\/div>\n\n\t

\n\t\t
\n\t\t\t

Instant cement with a special formula for leveling floors such as garages, sidewalks, pedestrians, old concrete grading.<\/p>\n\n\t\t<\/div>\n\t<\/div>\n<\/div><\/div><\/div><\/div><\/div><\/section><\/div>

<\/span><\/div>\n\t
\n\t\t\n\t\t
\n\t\t\t
\"MM-502\"<\/div>\n\t\t<\/figure>\n\t<\/div>\n
<\/span><\/div><\/div><\/div><\/div>
<\/span><\/div>
<\/span><\/div>\r\n\t

\r\n\t\t\t\r\n\t\t\t\tHOW TO USE\r\n\t\t\t<\/span>\r\n\t\t<\/h3>

1. Clean the surface from dirt that can reduce adhesion.
\n2. Pour MM-502 into clean water gradually.
\n3. Mixture ratio: 4.5-5.0 liter\/40 kg. Stir the mixture until smooth.
\n4. Use a long margin of aluminum steel.
\n5. If the surface of the brick is too dry, make it wet with clean water.
\n6. The recommended application thickness is 1-3 cm.
\n7. Pot life: 20 \u2013 30 minutes<\/p>\n

WORKING TOOLS<\/strong>
\nIron or steel trowel, long margin of steel or aluminum, hand mixer.<\/p>\n<\/div><\/div><\/div>\r\n\t

\r\n\t\t\t\r\n\t\t\t\tBENEFITS\r\n\t\t\t<\/span>\r\n\t\t<\/h3>

1. Has a high strength equivalent to the quality of concrete and is plastic when applied
\n2. Can be used for interior and exterior
\n3. Has a low expansion and shrinkage
\n4. Can also be applied on solid ground.
\n5. Consistent quality.<\/p>\n<\/div><\/div><\/div>\r\n\t

\r\n\t\t\t\r\n\t\t\t\tSPEAD COVERAGE\r\n\t\t\t<\/span>\r\n\t\t<\/h3>

\u00b1 1 m2 \/ 40 kg \/ 20 mm<\/p>\n

COMPRESSIVE STRENGTH<\/strong>
\nDIN 18555 Part 3 : 30-35 N\/mm2 @28 days
\nWATER RETENTION<\/strong>
\nDIN 18555 part 7 : > 95%
\nDRYING SHRINKAGE<\/strong>
\nASTM C 596-01 : < 0,1%<\/p>\n

USE<\/strong>
\nMM-502 can be applied on a variety of surfaces, namely:
\n1. Solid and level ground
\n2. Concrete floor surface
\n3. Rebate floor surface<\/p>\n<\/div><\/div><\/div>\r\n\t

\r\n\t\t\t\r\n\t\t\t\tSTORAGE\r\n\t\t\t<\/span>\r\n\t\t<\/h3>

Simpan di dalam ruangan tertutup, kering, terhindar dari percikan air. Simpan di atas pallet. Hindari tumpukan berlebih, maksimal 10 tumpuk\/pallet<\/p>\n

EXPIRED TIME<\/strong>
\n12 months when stored in closed and dry packaging<\/p>\n<\/div><\/div><\/div><\/div><\/div><\/div><\/div><\/div><\/section><\/div>

<\/span><\/div>
<\/span><\/span><\/span><\/span>\n<\/div>
<\/span><\/div>
<\/span><\/div>

FLOOR HARDENER<\/h3>\n\t
\n\t\t
\n\t\t\t

<\/strong>MM-503<\/strong><\/p>\n\n\t\t<\/div>\n\t<\/div>\n\n\t

\n\t\t
\n\t\t\t

Instant cement with a special formula as a scratch-resistant concrete floor coating for parking buildings, workshops, etc.<\/p>\n\n\t\t<\/div>\n\t<\/div>\n<\/div><\/div><\/div><\/div><\/div><\/section><\/div>

<\/span><\/div>\n\t
\n\t\t\n\t\t
\n\t\t\t
\"MM-503\"<\/div>\n\t\t<\/figure>\n\t<\/div>\n
<\/span><\/div><\/div><\/div><\/div>
<\/span><\/div>
<\/span><\/div>\r\n\t

\r\n\t\t\t\r\n\t\t\t\tHOW TO USE\r\n\t\t\t<\/span>\r\n\t\t<\/h3>

1. Above the remaining water on the wet concrete surface, evenly sprinkle 2\/3 of the MM-503 material that will be used to cover the concrete surface, leave it until the MM-503 sow becomes wet because it takes the remaining water from the concrete below.
\n2. Using a wooden trowel or trowel, compact the first layer and remove excess parts so that a flat initial surface is obtained. after 1-2 hours, sprinkle the remaining 1\/3 of the MM-503 that has not been sprinkled over the first layer.
\n3. Do rubbing MM-503 using a trowel carefully, this rubbing process is done repeatedly.<\/p>\n

WORKING TOOLS<\/strong>
\nTrowel<\/p>\n<\/div><\/div><\/div>\r\n\t

\r\n\t\t\t\r\n\t\t\t\tBENEFITS\r\n\t\t\t<\/span>\r\n\t\t<\/h3>

1. The surface of the concrete floor becomes harder.
\n2. Resistant to surface friction.
\n3. The floor does not become slippery and can be used in wet areas.
\n4. Suitable for warehouse, supermarket, workshop, showroom etc.<\/p>\n<\/div><\/div><\/div>\r\n\t

\r\n\t\t\t\r\n\t\t\t\tSPEAD COVERAGE\r\n\t\t\t<\/span>\r\n\t\t<\/h3>

\u00b1 14 m2 \/ 40 kg (3 kg\/m2)
\n\u00b1 7 m2 \/ 40 kg (5 kg \/ m2)
\n\u00b1 5 m2 \/ 40 kg (7 kg\/ m2)<\/p>\n

COMPRESSIVE STRENGTH<\/strong>
\nASTMC : 50-60 N\/mm2 @28 days.<\/p>\n

USE<\/strong>
\n1. MM-503 is used as a surface hardener for concrete floors to be resistant to scratches when passed by light to medium workloads
\n2. Application of 14 kg\/m2 for supermarkets, corridors, pedestrians, carports, etc.
\n3. Application of 7 kg\/m2 for parking area, showroon, workshop etc
\n4. Application of 5 kg\/m2 for factory area, parking area, warehouse etc
\n5. For the basis of load-bearing strength, still consider the concrete used.<\/p>\n<\/div><\/div><\/div>\r\n\t

\r\n\t\t\t\r\n\t\t\t\tSTORAGE\r\n\t\t\t<\/span>\r\n\t\t<\/h3>

Store in a closed, dry room. Avoid excessive stacks, maximum 8 stacks\/pallet (maximum 2 pallet stacks)<\/p>\n

EXPIRED TIME<\/strong>
\n12 months when stored in closed and dry packaging<\/p>\n<\/div><\/div><\/div><\/div><\/div><\/div><\/div><\/div><\/section><\/div>

<\/span><\/div>
<\/span><\/div><\/div><\/div><\/div><\/div><\/div><\/section><\/div>","protected":false},"excerpt":{"rendered":"PERATA LANTAI MM-501 Semen instan dengan formula khusus untuk pengerjaan perata lantai, menambah ketinggian lantai atau sebagai lantai kerja sebelum pemasangan keramik. CARA PEMAKAIAN 1. Bersihkan permukaan dari kotoran-kotoran yang dapat mengurangi daya rekat. 2. Tuangkan MM-501 ke dalam air bersih secara bertahap. 3. Perbandingan campuran: 9-9,5 liter\/40 kg. Aduk","protected":false},"author":1,"featured_media":0,"parent":0,"menu_order":0,"comment_status":"closed","ping_status":"closed","template":"","meta":[],"yoast_head":"\nPerata Lantai - PT. Multi Mortar<\/title>\n<meta name=\"robots\" content=\"index, follow, max-snippet:-1, max-image-preview:large, max-video-preview:-1\" \/>\n<link rel=\"canonical\" href=\"https:\/\/www.multimortar.com\/en\/perata-lantai\/\" \/>\n<meta property=\"og:locale\" content=\"en_US\" \/>\n<meta property=\"og:type\" content=\"article\" \/>\n<meta property=\"og:title\" content=\"Perata Lantai - PT. Multi Mortar\" \/>\n<meta property=\"og:url\" content=\"https:\/\/www.multimortar.com\/en\/perata-lantai\/\" \/>\n<meta property=\"og:site_name\" content=\"PT. Multi Mortar\" \/>\n<meta property=\"article:publisher\" content=\"https:\/\/www.facebook.com\/multimortar.official\" \/>\n<meta property=\"article:modified_time\" content=\"2021-01-21T07:45:05+00:00\" \/>\n<meta name=\"twitter:card\" content=\"summary_large_image\" \/>\n<meta name=\"twitter:label1\" content=\"Written by\">\n\t<meta name=\"twitter:data1\" content=\"root\">\n\t<meta name=\"twitter:label2\" content=\"Est. reading time\">\n\t<meta name=\"twitter:data2\" content=\"5 minutes\">\n<script type=\"application\/ld+json\" class=\"yoast-schema-graph\">{\"@context\":\"https:\/\/schema.org\",\"@graph\":[{\"@type\":\"WebSite\",\"@id\":\"https:\/\/www.multimortar.com\/#website\",\"url\":\"https:\/\/www.multimortar.com\/\",\"name\":\"PT. Multi Mortar\",\"description\":\"multimortar.com\",\"potentialAction\":[{\"@type\":\"SearchAction\",\"target\":\"https:\/\/www.multimortar.com\/?s={search_term_string}\",\"query-input\":\"required name=search_term_string\"}],\"inLanguage\":\"en-US\"},{\"@type\":\"WebPage\",\"@id\":\"https:\/\/www.multimortar.com\/perata-lantai\/#webpage\",\"url\":\"https:\/\/www.multimortar.com\/perata-lantai\/\",\"name\":\"Perata Lantai - PT. Multi Mortar\",\"isPartOf\":{\"@id\":\"https:\/\/www.multimortar.com\/#website\"},\"datePublished\":\"2020-10-13T04:01:47+00:00\",\"dateModified\":\"2021-01-21T07:45:05+00:00\",\"inLanguage\":\"en-US\",\"potentialAction\":[{\"@type\":\"ReadAction\",\"target\":[\"https:\/\/www.multimortar.com\/perata-lantai\/\"]}]}]}<\/script>\n","_links":{"self":[{"href":"https:\/\/www.multimortar.com\/en\/wp-json\/wp\/v2\/pages\/9605"}],"collection":[{"href":"https:\/\/www.multimortar.com\/en\/wp-json\/wp\/v2\/pages"}],"about":[{"href":"https:\/\/www.multimortar.com\/en\/wp-json\/wp\/v2\/types\/page"}],"author":[{"embeddable":true,"href":"https:\/\/www.multimortar.com\/en\/wp-json\/wp\/v2\/users\/1"}],"replies":[{"embeddable":true,"href":"https:\/\/www.multimortar.com\/en\/wp-json\/wp\/v2\/comments?post=9605"}],"version-history":[{"count":15,"href":"https:\/\/www.multimortar.com\/en\/wp-json\/wp\/v2\/pages\/9605\/revisions"}],"predecessor-version":[{"id":9965,"href":"https:\/\/www.multimortar.com\/en\/wp-json\/wp\/v2\/pages\/9605\/revisions\/9965"}],"wp:attachment":[{"href":"https:\/\/www.multimortar.com\/en\/wp-json\/wp\/v2\/media?parent=9605"}],"curies":[{"name":"wp","href":"https:\/\/api.w.org\/{rel}","templated":true}]}}